Etanol.nu

Forum för föreningen etanol.nu
Aktuellt datum och tid: tor 24-03-28 23:55

Alla tidsangivelser är UTC + 1 timme




Ny tråd Svara på tråd  [ 4 inlägg ] 
Författare Meddelande
 Inläggsrubrik: Total car diagnostics
InläggPostat: fre 13-08-23 17:22 
Offline
Forumadministratör
Användarvisningsbild

Blev medlem: lör 06-12-23 09:31
Inlägg: 7134
Ort: Älvsjö
Är det någon som känner till Total car diagnostics eller kollat på det http://www.totalcardiagnostics.com/ ?

Det verkar intressant, de påstår att man an mappa om bilens ECU med det.
http://www.totalcardiagnostics.com/supp ... map-tuning

Citat:
Basic Guide to DIY ECU Map Tuning (Using HEX Editor)

This is a brief introduction on how to tune a sample car map file.

NOTE: This is only a very brief introduction to tuning. There are many forums online on how to edit map files.


STEP 1: Download the stock ECU load from the vehicle. This image is the raw data from the ECU memory and is the application and Operating System code for the ECU. It controls how the car runs. Above the code area you will find the Constants and Maps, among other things. Take a look at the figure below...
Bild


In the hex dump window you see a series of highlighted bytes, 43 7A 00 00, and in the Inspector window you see "Float 250".

This is showing a map or constant value, in 32 bit floating point format, of 250.

The next series of 4 bytes, 43 FA 00 00, is a value of 500.

A value of 00 00 00 00 is a zero value.

Notice there are lots of 32 bit floats in the area of memory. This is part of a table.

The 20 values shown are:

250, 500, 0,0, 9, 800, 1200, 1600, 2000, 2400, 2800, 3200, 3600, 4000, 4400, 4800, 5200, 5600, 6000 and 6400.

The values 200 and 500 are not RPM based on the magnitudes (RPM would not normally be lower than 650), the values 800 thru 6400 are most likely RPM values used in a lookup table or map.

What is a Map? Look at the array below...

The numbers in red represent RPM values, the green numbers represent Mass Air Flow and the numbers in the yellow matrix represent fuel injector pulse width.

The longer the injector pulse the more fuel gets injected into the rotor.

To find this table you would look for ascending RPM values, ascending MAP values and many fuel injector pulse values, RPM X MAP numbers, in this case 13X9. This is a purely hypothetical MAP for illustration only.

Going back to the ECU hex dump, the ascending RPM numbers could be the start of a fuel map, or it could be a timing map, or possibly a map to control oil injection, at this time we don't know the definition of that map.

To find a Constant, you need to know what to look for.

An RPM limit would be a 32bit float at 9000 for a standard transmission car or 7500 for a automatic.

You would do a search for "46 0C A0 00" to find all values of 9000.

Pick one and change to 8000 and see if you hit the RPM limit.

Not all values are stored as floats, there are also single byte values of 0-255, unknown if 16 bit integers are used.

Once you take a look at the MAP area in memory, you will see it's nearly all floats or byte values.

TOAD ECU Editor lets you locate the maps, faster and easier within the file.

_________________
Komplettera gärna data om dit piggybacksystem här: http://www.editgrid.com/user/aryan/E85_piggyback_system och här viewtopic.php?f=10&t=6352


Dela på FacebookDela på TwitterDela på TuentiDela på SonicoDela på FriendFeedDela på OrkutDela på DiggDela på MySpaceDela på DeliciousDela på TechnoratiDela på TumblrDela på Google+
Upp
 Profil  
 
 Inläggsrubrik: Re: Total car diagnostics
InläggPostat: tor 13-08-29 15:06 
Offline
Forummoderator

Blev medlem: mån 07-01-01 20:57
Inlägg: 6015
Ort: Hindås
Är säkert bra, men kan finnas billigare.
En förutsättning är dock att bilen kan accessas bra med ELM327 interface, vilket tyvärr inte är fallet för alla bilmodeller.

_________________
http://direktdemokraterna.se
Myndigförklara dig själv.


Upp
 Profil  
 
 Inläggsrubrik: Re: Total car diagnostics
InläggPostat: tor 13-08-29 22:19 
Offline
Forumadministratör
Användarvisningsbild

Blev medlem: lör 06-12-23 09:31
Inlägg: 7134
Ort: Älvsjö
Skulle man kunna mappa om en bil för E85 med denna eller liknande mjukvara?

_________________
Komplettera gärna data om dit piggybacksystem här: http://www.editgrid.com/user/aryan/E85_piggyback_system och här viewtopic.php?f=10&t=6352


Upp
 Profil  
 
 Inläggsrubrik: Re: Total car diagnostics
InläggPostat: fre 13-08-30 12:32 
Offline
Forummoderator

Blev medlem: mån 07-01-01 20:57
Inlägg: 6015
Ort: Hindås
aryan skrev:
Skulle man kunna mappa om en bil för E85 med denna eller liknande mjukvara?


Jag tror det är möjligt med rätt kunskap.

_________________
http://direktdemokraterna.se
Myndigförklara dig själv.


Upp
 Profil  
 
Visa inlägg nyare än:  Sortera efter  
Ny tråd Svara på tråd  [ 4 inlägg ] 

Alla tidsangivelser är UTC + 1 timme


Vilka är online

Användare som besöker denna kategori: Inga registrerade användare och 7 gäster


Du kan inte skapa nya trådar i denna kategori
Du kan inte svara på trådar i denna kategori
Du kan inte redigera dina inlägg i denna kategori
Du kan inte ta bort dina inlägg i denna kategori
Du kan inte bifoga filer i denna kategori

Sök efter:
Hoppa till:  
POWERED_BY
Swedish translation by Peetra & phpBB Sweden © 2006-2011